像一些泥土之類的，需要水泥自動攪拌車邊攪拌邊運輸，泥土含有一定的水分，一旦水分少了它就會變干，因此需要在運輸過程中慢慢攪拌，氣路系統作為攪拌車常用的一種部件，攪拌車的氣路系統的保養應該怎么做？

For example, some soil needs to be transported while being mixed by an automatic cement mixer. The soil contains certain moisture, which will become dry once the moisture is less. Therefore, it needs to be mixed slowly during transportation. As a common component of the mixer, the air system should be maintained?

1、水泥自動攪拌車空氣壓縮機應水平放置、固定，通風良好。

1. The air compressor of automatic cement mixer shall be placed horizontally, fixed and well ventilated.

2、不能經受風吹雨淋，也不能暴曬在陽光下。

2. It shall not be exposed to the wind, rain or sun.

3、調整好空氣壓力自動開關的上下限值，壓力過低會導致氣缸動作遲緩，壓力過高對氣路系統密封件不利。

3. Adjust the upper and lower limits of the automatic air pressure switch. If the pressure is too low, the cylinder will act slowly. If the pressure is too high, it will be harmful to the seals of the air circuit system.

4、檢查水泥自動攪拌車潤滑油的油位，保持油面在油尺上下線之間，油面接近下線時，添加新油。

4. Check the lubricating oil level of the cement automatic mixer truck, keep the oil level between the upper and lower lines of the dipstick, and add new oil when the oil level is close to the lower line.

5、檢查傳送帶張力是否合適，當用手指壓皮帶，皮帶下陷10mm左右為宜；更換傳送帶時應整組更換，以保持張緊度一致。

5. Check whether the belt tension is appropriate. When pressing the belt with fingers, the belt should sink about 10mm; When replacing the conveyor belt, replace the whole group to keep the same tension.

此外如果你在下雨后不及時洗車，它會對你的車漆造成很大的損害，所以在雨后洗車比以往任何時候都更重要。酸雨經常含有雜質，在車輛被雨淋后，很長時間不清潔，酸會腐蝕一層明亮漆膜的外觀，油漆會變得暗淡無光。

In addition, if you don't wash the car in time after rain, it will cause great damage to your car paint, so it is more important than ever to wash the car after rain. Acid rain often contains impurities. If the vehicle is not cleaned for a long time after being exposed to rain, the acid will corrode the appearance of a bright paint film and the paint will become dull.

此外，瀝青、泥土和泥土在雨中混合也很容易吸收。這些污垢會在日曬后產生大量的氧化物，時間長，水泥自動攪拌車漆面會出現疤痕，所以越雨越應注意清洗水泥自動攪拌車。

In addition, asphalt, soil and soil are easily absorbed when mixed in the rain. These dirt will produce a large amount of oxides after being exposed to the sun, and the paint surface of the cement automatic mixer will show scars for a long time. Therefore, the more rain, the more attention should be paid to cleaning the cement automatic mixer.

氣路系統對于水泥自動攪拌車來說也是一處重要的部件，需要添加充足的油，并且保持油量充足，足夠攪拌車的運行，在提高攪拌車的使用效率的同時，也能加強對氣路系統的保養。更多相關內容就來我們網站http://m.top2010.cn留言咨詢吧！

The air circuit system is also an important part for the automatic cement mixer. It is necessary to add enough oil and keep enough oil to run the mixer. While improving the use efficiency of the mixer, it can also strengthen the maintenance of the air circuit system. More relevant content will come to our website http://m.top2010.cn Leave a message for consultation!